Numerical Simulation of Flow Field in Spiral Separator

ZHAO Hongyu

Abstract


Using the method of numerical simulation for PHOENICS, the paper gives a quantitative analysis about the distribution of flow field and pressure field for different viscosity and flow rate. The results show that: In the spiral flow, its tangential velocity is much larger than other velocity; with the increasing of the flow rate and polymer concentration, the speed for pressure drop is increasing; the change of internal pressure within the separator is not uniform. The simulation result scan supply reference for future research about spiral flow field within the piral separator.
Key words: Spiral separator; Spiral flow; PHOENICS; Power-law fluid


Keywords


Spiral separator; Spiral flow; PHOENICS; Power-law fluid

Full Text:

PDF

References


[1] Zhao, Y. B. (2007). Spiral flow before application of in industry. Shanxi Water Resources, (1), 74-75.

[2] Han, H. S., & Yao, H. Y. (2008). Numerical simulation of the air flow of power law fluid annulus based on PHOENICS and PIV. Journal of Daqing Petroleum Institute, 6(32), 46-49.

[3] Li, X. Z., Chen, W. M., Chu, L. Y. (2000). Hydroclone definition and composition of energy consumption analysis. Filtration and Separation, 10(2), 1-3.

[4] Zhu, L. Y., & Wu, C. G. (1998). Control and energy consumption of turbulent structure control and energy consumption of hydraulic cyclone. Journal of Chemical Engineering, 49(6), 760-763.

[5] Urselmann, R., Cummins, J., Worrall, R. N., & House, G. (1998, March). Pressured mud cap drilling: Efficient drilling of high pressure fractured reservoirs. Paper presented at SPE/IADC Drilling Conference, Amsterdam, Netherlands.

[6] Xu, J. R., & Rosie (1998). Hydrocyclone flow field theory. Beijing, China: Science Publishing Society.

[7] Zhu, L. Y., & Chen, W. M. (1998). Hydrocyclone. Beijing, China: Chemical Industry Press

[8] Tao, W. Q. (1988). Numerical heat transfer. Xi'an, China: Xi'an Jiao Tong University Press.

[9] Zhang, Y. J. (2007). PIV experimental study on the turbulent flow of a power law fluid in eccentric annulus (Doctoral dissertation). Daqing Petroleum Institute, Daqing, China.

[10] Xing, J. (2008). Numerical simulation and PIV experimental study of the flow of power law fluid (Doctoral dissertation). Daqing Petroleum Institute, Daqing, China.




DOI: http://dx.doi.org/10.3968/6808

Refbacks

  • There are currently no refbacks.


Copyright (c)



Share us to:   

Reminder

 We are currently accepting submissions via email only.

The registration and online submission functions have been disabled.

Please send your manuscripts to [email protected]，or  [email protected]  for consideration. We look forward to receiving your work.

 

We only use three mailboxes as follows to deal with issues about paper acceptance, payment and submission of electronic versions of our journals to databases:
[email protected]; [email protected]; [email protected]

 Articles published in Advances in Petroleum Exploration and Development are licensed under Creative Commons Attribution 4.0 (CC-BY). 

ADVANCES IN PETROLEUM EXPLORATION AND DEVELOPMENT Editorial Office

Address:1055 Rue Lucien-L'Allier, Unit #772, Montreal, QC H3G 3C4, Canada.

Telephone: 1-514-558 6138
Website: Http://www.cscanada.net
Http://www.cscanada.org
E-mail:[email protected];  [email protected]

Copyright © 2010 Canadian Research & Development Centre of Sciences and Cultures